Product ID:CSD 857 B
MSDS Date:12/01/1989
FSC:8010
NIIN:00-160-5786
MSDS Number: BHWYT

ASHLAND CHEMICAL CO. DIV. OF ASHLAND OIL INC

3849 FISHER ROAD
COLUMBUS, OH 43216
US

Emergency Phone: 614-889-3333

Info Phone: 606-324-1133

Cage: 7L600

CSD

3087 CONROE, TX 77305 US

Telephone: 409-756-1065/1083 FAX DAVID /SHANAN

Cage: SW216

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 15-20%

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9192

ISOBUTYL ACETATE (SARA III)

CAS: 110-19-0

RTECS: AI4025000

Fraction By Weight: 30-35%

OSHA PEL 150 PPM

ACGIH TLV: 150 PPM; 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ALIPHATIC PETROLEUM DISTILLATES

CAS: 34742-89-8

Fraction By Weight: 15-20%

OSHA PEL 400 PPM

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 12%

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 12%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYES: IRRITATION, REDNESS, TEARING MAY
CAUSE OTHER EYE DAMAGE. INHAL: IRRITATION TO NASAL
AND RESPIRATORY, CENTRAL NERVOUS SYSTEM SKIN: IRRI. TO DERMATITIS,
INGEST: LIVER ABNORMALITI ES, KIDNEY, MAY CAUSE ASPIRATION INTOTHE
LUNGS, PNEUMONITIS WHICH CAN BE FATAL.
Effects of Overexposure:EYES: IRRITATION, REDNESS, TEARING SKIN:
PROLONGED OR REPEATED CONTACT CAN CAUSEMODERATE IRRIT. DEFATTING,
DERMARTITIS. INHAL: IRRITATION TO RESPIR SYS, CNTRL NERV SYS,
DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE, UNCONSCIOUSNESS,
FATALINGEST: GASTROINTESTINAL IRRI. NAUSEA, VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:EYE DAMAGE: SKIN: DERMATITIS INHAL:
IRR. RESP. LUNG, CNTRL NERV. BRAIN DAMAGE, LIVER ABNORM. KID NEY
INGEST: GASTRO/PNEUMONITIS WHICH CAN BE FATAL

First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER, LIFTING UPPER AND
LOWER LIDS WHILE FLUSHING. SKIN: THOROUGHLY WAS EXPOSED AREA
WITH SOAP AND WATER. REMOVE CONTAM. CLOTHING WASH BEFORE REUSE.
INHAL: REMOV E PERSON TO FRESH AIR IF BREATHING ISDIFFICULT ADMIN.
OXYGEN/CPF. KEEP PERSON WARM GET MED. ATTEN. INGEST: DO NOT
INDUCE VOMITING KEEP PERSON WARM GET MED. ATTEN. ASPIR. INTO LUNGS
MAY BE FATAL.

Flash Point Method:TCC
Flash Point:19F/-7.2C
Extinguishing Media:REGULAR FOAM OR CARBON DIOXIDE OR DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS WITH A
FULL FACEPIECE OPERATED IN THE POSITIVE PRESSURE DEMAND MODE WHEN
FIGHTING FIRES.
Unusual Fire/Explosion Hazard:ALL CNTRS SHOULD BE GROUNDED/BONDED,
PROD. IS HIGHLY EXPLOSIVE, VPRS MAY TRAVEL AT GROUND/BY VENT TO
IGNITABLE SOURCE OF HEAT, SPARKS, FLAMES, SATIC DISCHARGE.

Spill Release Procedures:SMLL: ABSORB LIQUID ON PAPAER, VERMICULITE,
FLOOR ABSORB/ABSORB MATERIAL. LRG: ELIM ALL ING. SOURCESSTOP SPILL
AT SOURCE DIKE AREA TO PREVNT SPREADINGPUMP LIQ. TO SALVGE TANK.
REMANING USE SAND/CLAY/ EARTH/FLOOR ABSORBENT AND SHOVEL INTO
CONTAINERS.

Respiratory Protection:USE A NIOSH/MSHA APPROVED AIR SUPPLIED RESP OR
OSHA REG MUST BE A NEGATIVE PRES SURE TYPE, WHEN EXPOSURE LIMTS ARE
EXCEEDED, TO MAINTAIN OR IMPLEMENT PROPER VENTILATION WHEN USING
PRODUCT.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST)TO MAINTAIN EXPOSURE BELOW TLV LEVELS PERMITTED.
Protective Gloves:NITRIL RUBBER, POLYETHYLENE RESISTANT
Eye Protection:CHEMICAL SPLASH GOGGLES
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS.
Supplemental Safety and Health
TO PREVENT REPEATED OR PROLONGED SKIN CONTACT, WEAR IMPERVIOUS CLOTHING
AND BOOTS, AND FOLLOW MANUFACTURERS SAFETY PRECAUTIONS.

Spec Gravity:<1.000
Evaporation Rate & Reference:SLOWER THAN ETHER

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ALL IGNITABLE SOURCES TO EXPOSURE OF THIS
PRODUCT.
Stability Condition to Avoid:FLAMMABLE LIQUID PRODUCT. STRONG OXIDIZING
AGENTS.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS, CARBON
DIOXIDE AND CARBON MONOXIDEVARIOUS HYDROCARBONS.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
ANDFEDERAL REGULATIONS. SINCE EMPTIED
CONTAINERS RETAIN PRODUCT RESIDUES ALL CONTAINERS OF THIS PROD.
MAY BE HAZARDOUS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.